MasterCraft Trailer Spezifikationen

Trailer ManualTrailer Manual

A truck or van using a step bumper as the hitch platform will need to have safety cable attachments such as eye-bolts, as well as a hitch ball, whic

As noted above, the trailer hitch should provide a place for at-taching safety cables, through holes or rings on both sides of the hitch ball.

Never use the winch handle as a handle for pulling or maneuvering the en-tire trailer or other equipment. Never pull on the winch handle against a l

Master Cylinder Level Regularly verify that the brake fluid level comes to the top of the reservoir (as marked). MasterCraft’s speci-fi

If the coupler becomes damaged it must be repaired or replaced prior to tow-ing. When the coupling is placed on the ball, the latch should close firm

Wheels and Hubs Because they are often ex-posed to water, trailer wheels and tires require more atten-tion than the wheels on a fam-ily

When tightening the lug nuts, use the correctly sized wrench. e wrong size can round off the lug nuts and ren-der them useless. If yo

the lug nut torque is not maintained over more than one re-torque appli-cation because this indi-cates there is something potentially wro

would indicate water intrusion and the lubricant should be re-placed. Also check the seals for damage. When on a trip, make it a habit to check t

When trailer tires become worn or damaged, replace them with new tires. An authorized MasterCraft dealer can help you. For safety and con

The MasterCraft TrailerCONGRATULATIONS on the selection of a MasterCraft trailer. It is the ideal match for MasterCraft boats. e quality, innovati

against the hitch ball applies pressure to a master cylin-der in the trailer coupler. is pressure activates the trailer brakes through a h

Tie-Downs Ensuring that a MasterCraft boat will be held securely in place on the trailer’s hull sup-port, especially when under-way, is

safer—than pulling the trail-er to the car or truck.• Check to be sure the coupler locking device is released.• Raise the front end of the trai

• Check the rear view mirrors. If not already equipped with them, install outside rear view mirrors on both sides of the tow vehicle. Make it a habit

a very slow speed and try to avoid braking, except when the wheels are straight ahead and the trailer and tow vehicle are in line. If the trailer beg

• Prepare for launching. Install the drain plugs and detach the trailer tie-downs.• Slowly back the trailer down the ramp. If possible, have s

Storage When the MasterCraft trailer will not be in use for several months, the follow-ing steps may increase the life and performance of the trail

with an auto wax will also help to keep the trailer bright and clean.• Make up a special boating kit and carry it with you on all trips. e kit shoul

Limited Warranty Statement1. Limited Warranty and Term. MasterCraft Boat Company, LLC (“MasterCraft”) warrants to the original retail purchaser th

and/or(l) all warranted coverage will expire after ninety (90) days on trailers used for commercial purposes.3. Disclaimer and Limitation of Imp

e maintenance, service and repair procedures described in this Manual should be performed only by trained and authorized factory personnel or dealer

Only one (1) transfer under the provisions of this Section 5 (from the original retail purchaser to the second owner), within the applicable time pe

MaintenanceBefore Initial Use:• Read the Owner’s Manual completely.Before Every Trip:• Verify that the tongue weight and load are within proper sp

MasterCraft Boat Company, L.L.C.100 Cherokee Cove DriveVonore TN 37885423-884-2221

local ordinances regarding driving and towing. MasterCraft also recommends a thorough review of applicable insurance coverage and any insurance ca

11. Keeptiresproperlyinated.Inspecteachtire’spressurebeforeeachuse.Refertothetiresidewallforproperination.Failuretomaintainth

this is not covered by the Limited Warranty for the trailer. To avoid this situ-ation, consider attaching mud flaps behind the tow ve

Introduction With the purchase of a new MasterCraft trailer, custom-built to integrate with a MasterCraft boat, value has been added to the boating

Load-Carrying Capacity Check the metallic certification label attached to the front left side of the trailer. It will show the maximum

Weight Distribution Improper weight distribution can cause a boat trailer to fishtail (sway from side to side) as it moves down the highway, putti